Alfa Romeo Bulletin Board & Forums - Reply to Topic
Thread: while replacing radiator..? Reply to Thread
Title:
Message:
Post Icons
You may choose an icon for your message from the following list:
 

Register Now



In order to be able to post messages on the Alfa Romeo Bulletin Board & Forums forums, you must first register.
Please enter your desired user name, your email address and other required details in the form below.

User Name:
Password
Please enter a password for your user account. Note that passwords are case-sensitive.

Password:


Confirm Password:
Email Address
Please enter a valid email address for yourself.

Email Address:
OR

Log-in










  Additional Options
Miscellaneous Options

  Topic Review (Newest First)
07-31-2017 11:13 PM
BMX
Quote:
Originally Posted by adamreed31 View Post
Would love to bmX! not sure If I am confident enough with the install doing myself....I wish someone had a step by step/idiots guide for the conversion...have not see one.
Its surprisingly easy with a good kit, I used a cheap kit because I'm fine with DIY, but it sounds like your starting to learn your way round, you've done good so far, once you gain confidence you'll be itching to do other work on your Alfa, good start
07-31-2017 02:35 PM
60sRacer
Quote:
Originally Posted by alfazagato View Post
Change the plastic fan. They are notorious for failure, and not pretty.
I had one explode at a kinda high speed. The dents in the hood were a nightmare to fix.

Robert
07-31-2017 11:04 AM
adamreed31 OK .
Just a follow up .
Finally was able to complete radiator install on my 87 s3.
Replaced radiator with new unit from Vick, new upper and lower hoses, new clamps, new fan shroud.
Fan was in good order...not faded or brittle so I left it.
Bled out cooling system, replaced fluid, fired up....good to go!!
So far so good.
Was proud of myself for I have never replaced one before.

Thanks for all your input/guidance.
06-24-2017 10:23 AM
adamreed31 Would love to bmX! not sure If I am confident enough with the install doing myself....I wish someone had a step by step/idiots guide for the conversion...have not see one.
06-24-2017 10:11 AM
BMX Bin the fan and fit a pusher electric one, much more efficient and quiet
06-24-2017 09:45 AM
adamreed31 yeah...agreed. I'm thinking radiator, all hoses, all clamps, shroud (mine is cracked), and new fan....project creep!!!! warning! warning!
06-24-2017 09:10 AM
alfazagato Change the plastic shroud too if it cracked or missing bits. Makes a lot of difference.
06-24-2017 09:03 AM
Jim99 You should replace the fan. They are plastic an known to fail with age. It is not pretty when they come apart. Inexpensive
06-22-2017 02:31 PM
alfabeach Also makes it easier to get to distributor for changing cap and rotor.
06-22-2017 12:40 PM
spiderserie4 check waterpump for leaks
check front crankshaft oil seal for leaks
(both somewhat easier to inspect with rad removed)
06-22-2017 12:38 PM
Alfaboutvegas
mounts

The mounting brackets are available from almost all venders listed here on the board as well as any other you might choose.
inexpensive at least to change them, so,,, why not. Easier than having to after the radiator is re-installed.
06-22-2017 11:53 AM
bruce1976spider Probably just what you think - I have my whole engine out right now (which means the radiator came out too).

I'm replacing ALL of the radiator mounting padding, the two rubber bushings (if I can find them), the heater hoses (which aren't formed special - just generic hose). I'll check the thermostat.

I will flush my heater core too - because I had an OIL-in-the-antifreeze problem. Mine has an electric fan conversion that needs new wiring as well.
06-22-2017 11:41 AM
adamreed31
while replacing radiator..?

Hello all.

About to replace my defunct radiator.
It has been repaired more than once so I am going to just give it a clean slate.

My question is while replacing the radiator, what are some inexpensive things that should be replaced at same time?
hoses if crapped out/tired I assume?
plastic fan if tired?
fan belt?
Any input appreciated from those more experienced than I.

Thanks again!

Posting Rules  
You may post new threads
You may post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

 
For the best viewing experience please update your browser to Google Chrome